Product ID:CAF 9
MSDS Date:11/10/1987
FSC:5330
NIIN:01-038-3470
MSDS Number: BXTMT

TBA INDUSTRIAL PRODUCTS

ROCHDALE, LANCS, ENGLAND
EN

Emergency Phone: 800-527-1935

Info Phone: 800-527-1935

Cage: 01309

TBA INDUSTRIAL PRODUCTS

40 ROCHDALE, LANCS, PA 19124-5622 EN

Telephone: 800-527-1935

Cage: 01309

ASBESTOS, CHRYSOTILE

CAS: 12001-29-5

RTECS: CI6478500

Fraction By Weight: 65 - 70%

OSHA PEL 0.2 FIBERS/CC

ACGIH TLV: 2 FIBERS/CC,A1; 9495

INERT FILLERS

Fraction By Weight: 20%.

RUBBER BINDERS (NATURAL & SYNTHETIC)

Fraction By Weight: 12%

CURING AGENT

Fraction By Weight: 3%

LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT RELEVANT.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
TRACT. ACUTE- DUSTS/ASBESTOS FIBERS MAY CAUSE EYE, SKIN,
RESPIRATORY TRACT IRRITATION. MAY CAUSE REDUCED BREATHING CAPACITY.
INGESTION IS UNLIKELY. CHRONIC- EXPOS URE TO HIGH CONCENTRATIONS OF
ASBESTOS DUST INCREASES RISK OF DEVELOPING LUNG DISEASE. SMOKERS
ARE AT GREATER RISK.
Explanation of Carcinogenicity:CONTAINS A [1332-21-4] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:REDUCED LUNG CAPACITY, COUGHING, TEARING,
IRRITATION
Medical Cond Aggravated by Exposure:WORKERS WITH RESPIRATORY TRACT
DISORDERS

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER.
ORAL:UNLIKELY.

Flash Point:NONE
Extinguishing Media:WATER SPRAY, FOAM
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. ASBESTOS FIBERS MAY BE PRESENT.
Unusual Fire/Explosion Hazard:RUBBER BINDER MAY BURN.

Spill Release Procedures:TREAT DUST AS FREE ASBESTOS. DO NOT DRY SWEEP
OR USE COMPRESSED AIR. WET METHOD SHOULD BE USED FOR EXTRACTION OF
DUST AND DEBRIS. HIGH EFFICIENCY PARTICULATE APPARATUS (HEPA)
VACUUMS SHOULD BE USED.
Neutralizing Agent:NOT RELEVENT

Handling and Storage Precautions:STORE IN DRY, VENTILATED PLACE.
Other Precautions:WASH HANDS AFTER HANDLING. KEEP OUT OF REACH OF SMALL
CHILDREN. DO NOT DRILL, SAW, GRIND, SAND WITHOUT ADEQUATE DUST
EXTRACTION OR WETTING DOWN. APPROVED RESPIRATOR SHOULD BE WORN
DURING OPERATIONS WH ICH WILL RELEASE ASBESTOS FIBERS >TLV.

Respiratory Protection:IF TLV IS EXCEEDED OR FOR SYMPTOMS OF OVER
EXPOSURE, WEAR NIOSH-APPROVED RESPIRATOR FOR DUST OR AIR-PURIFYING
RESPIRATOR. IN EMERGENCY, WEAR A NIOSH-APPROVED POSITIVE-PRESSURE
SELF-CONTAINED BREATHING APPARATUS.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Protective Gloves:LATEX OR RUBBER RECOMMENDED
Eye Protection:GOGGLES
Other Protective Equipment:EYE WASH STATION; FULL BODY PROTECTION IF
ABOVE TLV
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health

HCC:N1
NRC/State Lic Num:NOT RELEVANT
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:INSOLUBLE
Appearance and Odor:RED SHEET MATERIAL - SLIGHT RUBBERY ODOR

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:CREATION OF DUST OR FUMES
Hazardous Decomposition Products:EMITS TOXIC RUBBER COMBUSTION
PRODUCTS.

Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. KEEP PERSONNEL AWAY. DISCARD ANY PRODUCT, RESIDUE,
DISPOSABLE CONTAINER OR LINER IN AN ENVIRONMENTALLY ACCEPTABLE
MANNER, IN FULL COMPLIANCE W ITH LOCAL, STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.